Contact us

Welcome to contact us through the hotline or other communication modes.

TOTAL SYSTEM EFFICIENCY : AN INTRODUCTION T

< 2018-8-5 · Condensing boiler heat exchangers are constructed of either stainless steel or aluminum construction as shown in Figures 1 & 2, which are more resistant to acid in the acidic condensate compared to non-condensing boilers that are made of cast iron, steel, or copper.

xuyi@zozen.com > Get A Quote >

Condensate Neutralization Kits - Harsco Industria

< Typical Condensate From a Condensing Boiler Has a pH level of 3.2 to 4.5. Due to condensate's acidic nature, we recommend installing neutralizer kits to protect drains and sewers from corrosion. Condensate Neutralization Kits raise the pH levels of the condensate so it

xuyi@zozen.com > Get A Quote >

The Proper Disposal of Boiler Condensate | U.S. Boile

< At U.S. Boiler, we install a condensate trap on our condensing boiler, so the use of a second trap is not recommended because a second trap could create operational problems for the boiler. The termination of the pump must also be installed so the condensate pump tank, tubing, or tube termination can't freeze.

xuyi@zozen.com > Get A Quote >

Condensafe+ | Sentin

< 2019-9-17 · In condensing boilers, high efficiency is achieved by using waste heat from the hot flue gases to pre-heat the water in the boiler instead of just being exhausted though the flue. However, in doing so, the flue gases are cooled and an acidic condensate is formed which is often simply discharged into the normal domestic drain.

xuyi@zozen.com > Get A Quote >

Acidic corrosion in boilers - Lennte

< Acidic corrosion. Hydrogen embitterment. Oxygen attack. Carbon dioxide attack Low make up feed water pH can cause serious acid attack on metal surfaces in the preboiler and boiler system. Feed water can also become acidic from contamination of the system (process contamination of condensate or cooling water contamination from condensers).

xuyi@zozen.com > Get A Quote >

How to treat condensate from boilers - Climat

< 2017-3-10 · How to treat condensate from boilers. By Sandra van Dijk | 10 March 2017. damage associated with acidic condensate in the drain piping can be avoided. The condensate expelled from a condensing water heater is acidic with a pH of between 2 and 4, so it is critical that the appropriate materials are used in all piping where this liquid is

xuyi@zozen.com > Get A Quote >

How toxic is furnace/boiler condensation? - Inspectin

< 2017-11-6 · I believe the condensate is acidic, about the same alkinity of cola. That is why you sometimes see a tube on the condensate waste line, which contains a neutralizer, as not to corrode waste lines. Ahh, 2 + 2= finally the answer 4. Condensate pan showing flow of condensate towards drain is rusted. Coke soda spilled on metal/show rust

xuyi@zozen.com > Get A Quote >

Condensate pump - Wikiped

< 2019-8-27 · A condensate pump is a specific type of pump used to pump the condensate (water) produced in an HVAC (heating or cooling), refrigeration, condensing boiler furnace, or steam system.

xuyi@zozen.com > Get A Quote >

How to treat condensate from boilers - Climat

< 2017-3-10 · How to treat condensate from boilers. By Sandra van Dijk | 10 March 2017. damage associated with acidic condensate in the drain piping can be avoided. The condensate expelled from a condensing water heater is acidic with a pH of between 2 and 4, so it is critical that the appropriate materials are used in all piping where this liquid is

xuyi@zozen.com > Get A Quote >

NBSeries Installation Operation & Maintenan

< 2015-6-5 · 6 Installation NB series Acidic Condensate pH Treatment Kits –– Installation/Operation & Maintenance A Condensing boiler furnace or hot water heater B Condensate neutralizing tank C Boiler/furnace condensate trap connection D Boiler/furnace vent E Vent condensate trap, when used — Install a trap as shown. F Drain or sump G Install 3/4 inch PVC vent piping to outside from vent

xuyi@zozen.com > Get A Quote >

Condensate from Condensing boiler - InspectionNe

< 2011-9-12 · Condensate from high efficiency boilers is very acidic. Can it be plumbed directly into the home's sanitary drain or does it have to be treated first? I was at a new home yesterday with 3 HTP high efficiency boilers being installed (500,000 btu each) and there is continuous condensate dumping from the units right into a sump well. Not sure if this won't affect the life of the sump pump.

xuyi@zozen.com > Get A Quote >

Related products
WNS series gas-fired (oil-fired) steam boiler

1-20 t/h | 0.7-2 Mpa

More Details
WNS series gas-fired (oil-fired) hot water boiler

0.7-14 MW | 0.7-1.25 Mpa

More Details
DZL series coal-fired hot water boiler

1.4-14 MW|0.7-1.25 MPA

More Details